Derivation of motor mean phase currents in PMSM drives operating with low switching-to-fundamental frequency ratio
Abstrakt
Pulse width modulation (PWM) of inverter output voltage causes the waveforms of motor phase cur-rents to consist of distinctive ripples. In order to provide suitable feedback for the motor current con-trollers, the mean value must be extracted from the currents’ waveforms in every PWM cycle. A com-mon solution to derive the mean phase currents is to sample their value at the midpoint of a symmetrical PWM cycle. Using an assumption of linear current changes in steady PWM subintervals, this midpoint sample corresponds to the mean current in the PWM cycle. This way no hardware filtering or high-rate current sampling is required. Nevertheless, the as-sumption of linear current changes has been recently reported as over simplistic in permanent magnet syn-chronous motor (PMSM) drives operating with low switching-to-fundamental frequency ratio (SFFR). This, in turn, causes substantial errors in the repre-sentation of the mean phase currents by the midpoint sample. This paper proposes a solution for deriving mean phase currents in low SFFR PMSM drives, which does not rely on the linear current change as-sumption. The method is based on sampling the cur-rents at the start point of a PWM cycle and correct-ing the sampled value using a model-based formula that reproduces the current waveforms. Effective-ness of the method is verified by simulation for an exemplary setup of high-speed PMSM drive. The re-sults show that the proposed method decreases the error of determining the mean phase currents approx-imately 10 times when compared to the classical midpoint sampling technique.
Cytowania
-
1
CrossRef
-
0
Web of Science
-
0
Scopus
Autor (1)
Cytuj jako
Pełna treść
- Wersja publikacji
- Accepted albo Published Version
- Licencja
- otwiera się w nowej karcie
Słowa kluczowe
Informacje szczegółowe
- Kategoria:
- Publikacja w czasopiśmie
- Typ:
- artykuły w czasopismach
- Opublikowano w:
-
Power Electronics and Drives
nr 4,
strony 95 - 102,
ISSN: 2451-0262 - Język:
- angielski
- Rok wydania:
- 2019
- Opis bibliograficzny:
- Jarzębowicz L.: Derivation of motor mean phase currents in PMSM drives operating with low switching-to-fundamental frequency ratio// Power Electronics and Drives -Vol. 4,iss. 39 (2019), s.95-102
- DOI:
- Cyfrowy identyfikator dokumentu elektronicznego (otwiera się w nowej karcie) 10.2478/pead-2019-0003
- Bibliografia: test
-
- Böcker, J. and Buchholz, O. (2013). Can oversampling improve the dynamics of PWM controls? In: Proceedings of 2013 IEEE International Conference on Industrial Technology (ICIT). Cape Town, 25-28 February 2013, pp. 1818-1824. otwiera się w nowej karcie
- El-Refaie, A., Raminosoa, T., Reddy, P., Galioto, S., Pan, D., Grace, K., Alexander, J. and Huh, K. K. (2017). Comparison of Traction Motors that Reduce or Eliminate Rare-Earth Materials. IET Electrical Systems in Transportation, 7, pp. 207-214. otwiera się w nowej karcie
- Gerada, D., Mebarki, A., Brown, N. L., Gerada, C., Cavagnino, A. and Boglietti, A. (2014). High-Speed Electrical Machines: Technologies, Trends, and Developments. IEEE Transactions on Industrial Electronics, 61, pp. 2946-2959. otwiera się w nowej karcie
- Jarzebowicz, L. (2017). Errors of a Linear Current Approximation in High-Speed PMSM Drives. IEEE Transactions on Power Electronics, 32(11), pp. 8254-8257. otwiera się w nowej karcie
- Jarzebowicz, L. and Mirchevski, S. (2017). Modeling the impact of rotor movement on non-linearity of motor currents waveforms in high-speed PMSM drives. In: Proceedings of 19th European Conference on Power Electronics and Applications (EPE'17 ECCE Europe). Warsaw, 11-14 September 2017. otwiera się w nowej karcie
- Kim, M., Sul, S.-K. and Lee, J. (2014). Compensation of Current Measurement Error for Current-Controlled PMSM Drives. IEEE Transactions on Industry Applications, 50, pp. 3365-3373. otwiera się w nowej karcie
- Kwon, Y.-C., Kim, S. and Sul, S.-K. (2014). Six- Step Operation of PMSM with Instantaneous Current Control. IEEE Transactions on Industry Applications, 50, pp. 2614-2625. otwiera się w nowej karcie
- Li, Z. and Gao, Q. (2018). A Prediction-Based Current Sampling Scheme Using Three Resistors for Induction Motor Drives. IEEE Transactions on Power Electronics, 33, pp. 6082-6092. otwiera się w nowej karcie
- Lu, J., Hu, Y. and Liu, J. (2018). Analysis and Compensation of Sampling Errors in TPFS IPMSM Drives with Single Current Sensor. IEEE Transactions on Industrial Electronics, 66, pp. 3852-3855. otwiera się w nowej karcie
- Oleschuk, V. and Barrero, F. (2014). Standard and Non- Standard Approaches for Voltage Synchronization of Drive Inverters with Space-Vector PWM: A Survey. International Review of Electrical Engineering (IREE), 9, pp. 688-707. otwiera się w nowej karcie
- Persson, E. (2002). Motor current measurement using time-modulated signals. In: Proceedings of the Power Conversion Conference. Osaka, 2-5 April 2002, pp. 716-720. otwiera się w nowej karcie
- Sandre-Hernandez, O., Rangel-Magdaleno, J. and Morales-Caporal, R. (2018). A Comparison on Finite-Set Model Predictive Torque Control Schemes for PMSMs. IEEE Transactions on Power Electronics, 33, pp. 8838-8847. otwiera się w nowej karcie
- Sepulchre, L., Fadel, M. and Pietrzak-David, M. (2016). Improvement of the digital control of a high speed PMSM for vehicle application. In: Proceedings of 2016 Eleventh International Conference on Ecological Vehicles and Renewable Energies (EVER). Monte-Carlo, 6-8 April 2016. otwiera się w nowej karcie
- Sobczyński, D. (2016). Review of Solutions Used in High Speed Induction Motor Drives Operating in Household Appliances. Power Electronics and Drives, 1(36), pp. 27-49.
- Tarczewski, T., Skiwski, M., Grzesiak, L. M. and Zieliński, M. (2018). PMSM Servo-Drive Fed by SIC MOSFETs Based VSI. Power Electronics and Drives, 3(38), pp. 35-45. otwiera się w nowej karcie
- Vukosavić, S. N., Perić, L. S. and Levi, E. (2016). AC Current Controller with Error-Free Feedback Acquisition System. IEEE Transactions on Energy Conversion, 31, pp. 381-391. otwiera się w nowej karcie
- Wang, W., Fan, Y., Chen, S. and Zhang, Q. (2018). Finite control set model predictive current control of a five-phase PMSM with virtual voltage vectors and adaptive control set. CES Transactions on Electrical Machines and Systems, 2, pp. 136-141. otwiera się w nowej karcie
- Wang, H., Yang, M., Niu, L. and Xu, D. (2010). Current- loop bandwidth expansion strategy for permanent magnet synchronous motor drives. In: Proceedings of the 5th IEEE Conference on Industrial Electronics and Applications (ICIEA), Taichung, 15-17 June 2010, pp. 1340-1345.
- Wolf, C. M., Degner, M. W. and Briz, F. (2015). Analysis of Current Sampling Errors in PWM VSI Drives. IEEE Transactions on Industry Applications, 51, pp. 1551-1560. otwiera się w nowej karcie
- Źródła finansowania:
- Weryfikacja:
- Politechnika Gdańska
wyświetlono 109 razy